Plasma-Derived Atomic Hydrogen Advances Low-Temperature CO₂ Methanation at High Yield

Scientists developed a new method that enables low-temperature carbon dioxide methanation using plasma-derived atomic hydrogen

November 26, 2024

Plasma-derived atomic hydrogen (PDAH) enables low-temperature carbon dioxide methanation reaction through the Eley−Rideal-type reaction channel, improving methane yield at low temperatures, as shown by scientists at Science Tokyo. The findings underscore the potential of PDAH in advancing sustainable carbon dioxide recycling methods and optimizing other catalytic hydrogenation reactions, providing a promising avenue for improved efficiency in various energy and environmental technologies.

New Energy-Efficient Carbon Dioxide Recycling Method Using Plasma-Derived Atomic Hydrogen

Plasma-derived atomic hydrogen enables Eley−Rideal-type CO2 methanation at low temperature Kim et al. (2024) | JACS Au

Plasma-derived atomic hydrogen enables Eley−Rideal-type CO₂ methanation at low temperature
Kim et al. (2024) | JACS Au

Despite declining reserves and significant carbon dioxide (CO₂) emissions contributing to climate change, fossil fuels continue to be the most widely used energy source globally. This pressing environmental issue has led researchers to seek methods for reducing atmospheric CO₂. One promising approach is CO₂ methanation, a process that converts CO₂ into methane–a cleaner fuel, by reacting it with green hydrogen in the presence of a metal catalyst.

CO₂ methanation is thermodynamically more efficient at low temperatures, ideally allowing the heat of the reaction to sustain it. However, in practice, this reaction must be conducted at high temperatures, requiring an external heat source. This is because the atomic hydrogen, formed by the adsorption and dissociation of hydrogen molecules on the catalyst surface, becomes immobilized and stabilized on the catalyst, reducing its reactivity and necessitating high temperatures to overcome the energy barrier for the rate-determining step. This creates challenges like high energy consumption, carbon deposition on the catalyst, and the formation of unwanted by-products such as carbon monoxide (CO). Fully harnessing the chemical reactivity of atomic hydrogen is crucial for improving CO₂ methanation.

To address these issues, a research team from Japan, led by Professor Tomohiro Nozaki, from the Department of Mechanical Engineering at the Institute of Science Tokyo, investigated an innovative plasma-assisted system that enables low-temperature CO₂ methanation using PDAH. Their findings were published in the journal JACS Au.

Plasma catalysis, which combines nonthermal plasma (NTP) with conventional metal-supported catalysts, has recently gained considerable attention due to the synergistic interactions it creates between the plasma and the catalyst. NTP consists of electrons at a much higher temperature than the bulk gas. “Studies have demonstrated low-temperature CO₂ methanation using plasma catalysis, but an understanding of the reaction dynamics and mechanisms is still lacking. Moreover, the nature and reactivity of PDAH has rarely been explored,” explains Nozaki.

To understand the underlying dynamics of plasma-assisted CO₂ methanation, the team conducted a detailed study using kinetic analysis, laser plasma diagnostics, in situ plasma surface characterization, and quantum chemistry calculations. They performed CO₂ methanation with Ni/Al₂O₃, as a non-precious metal catalyst, in a packed-bed dielectric barrier discharge (DBD) reactor. In this setup, a mixture of CO₂ and hydrogen gas is partially ionized, producing NTP and thus highly reactive PDAH.

The researchers found that the activity of CO₂ methanation under DBD conditions demonstrated high activity even at low temperatures below 300 ℃. Remarkably, at around 230 ℃, the CO₂ conversion rates under DBD conditions were 11 times higher than those achieved with thermal catalysis, while maintaining methane selectivity above 98%. Moreover, since DBD does not heat the product gas, it prevents the formation of unwanted by-products. Quantum chemistry calculations further revealed that PDAH lowers the energy barrier of the reaction intermediates by activating the Eley−Rideal-type reaction pathway, facilitating the low-temperature CO₂ methanation.

“Our study highlights the important role of PDAH in catalytic CO₂ methanation. Our findings can also be applied to other catalytic hydrogenation processes, including methanol, hydrocarbon, and ammonia production,” remarks Nozaki, highlighting potential applications.

Moreover, the Power-to-X concept would gain momentum with the plasma technologies driven by renewable energy, which also contributes to a low-carbon society.

Overall, this study provides new insights into plasma-assisted CO₂ methanation, paving the way for more energy-efficient and sustainable CO₂ recycling.

Reference

Authors:	Dae-Yeong Kim¹, Yoshinobu Inagaki², Tsukasa Yamakawa², Bang Lu³, Yoshiaki Sato³, Naoki Shirai², Shinya Furukawa⁴, Hyun-Ha Kim⁵, Satoru Takakusagi³, Koichi Sasaki², and Tomohiro Nozaki¹
Title:	Plasma-Derived Atomic Hydrogen Enables Eley–Rideal-Type CO₂ Methanation at Low Temperatures
Journal:	JACS Au
Affiliations:	¹ Department of Mechanical Engineering, Tokyo Institute of Technology, Japan ² Division of Applied Quantum Science and Engineering, Hokkaido University, Japan ³ Institute for Catalysis, Hokkaido University, Japan ⁴ Division of Applied Chemistry, Osaka University, Japan ⁵ National Institute of Advanced Industrial Science and Technology, Japan
DOI:	10.1021/jacsau.4c00857